rav 4

  1. MG

    2019-2020 Toyota RAV4 Hybrid Coverage for Vehicle Refueling Performance Customer Support Program 20TE04

    Please see Customer Support Program 20TE04 2019-2020 Toyota RAV4 Hybrid Coverage for Vehicle Refueling Performance In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Customer Support Program to provide coverage for Fuel Tank and Fuel Sender Gauge Unit...
  2. MG

    2019-2020 Toyota Rav4 Hybrid Vehicle Refueling Performance T-SB-0109-20

    **** This concern is now covered by a Customer Support Program (CSP 20TE04) found here... Please see T-SB-0109-20 Applicability: 2019-2020 RAV4 Hybrid Introduction: Some 2019 – 2020 model year RAV4 Hybrid vehicles may experience one or both of the following conditions:  The fuel gauge...
  3. OishiiJPN

    2016 Toyota Rav4 with ABS light on, codes U0129, U0235, B124B, C1AEC and Alternator may test bad

    Check for ECU-IG No.3 fuse blown also check for parasitic draw due to corrosion in connector AD1.
  4. MG

    2019-2020 Toyota Rav4 Hybrid MIL on P0AA649 / P1C8049 Corrosion on MGR Cable T-TT-0630-20

    Please see Tech Tip T-TT-0630-20 APPLICABLE VEHICLES: 2019-2020 RAV4 Hybrid CONDITION: Some 2019-2020 model year RAV4 HV vehicles may experience DTC codes P0AA649 / P1C8049. - P0AA649-Hybrid/EV Battery Voltage System Isolation Internal Electronic Failure - P1C8049-Hybrid/EV Battery Voltage...
  5. MG

    2019-2020 Toyota RAV4 and RAV4 Hybrid Front Brake Squeal Noise T-TT-0623-20

    Please see Tech Tip T-TT-0623-20 APPLICABLE VEHICLES: 2019-2020 RAV4 2019-2020 RAV4 Hybrid CONDITION: Some 2019-2020 model year RAV4 and RAV4 HV vehicles may exhibit a front brake squeal/squeak noise when braking at low speeds. RECOMMENDATIONS: Confirm a squeak/squeal noise is coming from...
  6. MG

    2021 Toyota RAV4 Prime Headlamp Beam Could be Improperly Adjusted Horizontally Recall 20TA15

    Please see Recall 20TA15 Check here to see if this Recall applies to your Toyota vehicle 2021 Toyota RAV4 Prime Headlamp Beam Could be Improperly Adjusted Horizontally On November 12, 2020, Toyota filed a Noncompliance Information Report (NCIR) with the National Highway Traffic Safety...
  7. MG

    2020-2021 Toyota Avalon, Avalon Hybrid, RAV4, RAV 4 Hybrid Steering Column Issue May Affect Airbag Performance Recall 20TA17

    Please see Recall 20TA17 Check here to see if this Recall applies to your Toyota vehicle 2020-2021 Toyota Avalon 2020 Toyota Avalon Hybrid 2020 Toyota RAV4 2020 Toyota RAV 4 Hybrid Steering Column Issue May Affect Airbag Performance On November 25, 2020, Toyota filed a Noncompliance...
  8. MG

    2019 Toyota Rav4 Abnormal Buzz/Groan Noise at 20-30mph Adventure Limited grade equipped with torque vectoring AWD system ONLY Tech Tip T-TT-0539-19

    Please see Tech Tip T-TT-0539-19 APPLICABLE VEHICLES: 2019 Toyota RAV4 CONDITION: This Tech Tip applies to 2019 model year RAV4 Adventure/Limited grade equipped with torque vectoring AWD system ONLY. Some customers may experience a buzz/groan at 20-30 mph when accelerating from a stop and/or...
  9. MG

    2019 Toyota RAV4 and RAV4 Hybrid Abnormal Noise from Rear Over Bumps T-TT-0550-19

    Please see Tech Tip T-TT-0550-19 APPLICABLE VEHICLES: 2019 RAV4 Hybrid 2019 RAV4 CONDITION: Abnormal noise from rear of vehicle when traveling over bumps. RECOMMENDATIONS: Inspect rear coil springs for evidence of rubbing on lower arm. Coil spring may also appear misaligned or not seated...
  10. MG

    2021 Toyota Models ECU Flash Reprogramming With Security Signature T-SB-0107-20

    Please see T-SB-0107-20 Applicability: 2021 RAV4 Prime, Sienna HV, Venza Hybrid Introduction: Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix...
  11. Lewis

    2019-2020 Toyota RAV4 and RAV4 Hybrid Squeak/groan noise from steering intermediate shaft area

    See Tech Tip T-TT-0582-19 CONDITION: Customer states that there is a squeak or groan noise from the steering column area when turning the steering wheel. RECOMMENDATIONS: Do not apply any lubricant or water to intermediate shaft or seal. This could damage the seal or lead to a repeat repair...
  12. Dread Pirate Roberts

    2019 Toyota Rav 4 and Rav 4 Hybrid Backup Camera System May Not Operate Recall K0N

    Recall Letter You can check the status of any Recall on your Toyota here. On August 6, 2019, Toyota filed a Noncompliance Information Report (NCIR) with the National Highway Traffic Safety Administration (NHTSA) informing the agency of our intent to conduct a voluntary Safety (Noncompliance)...
  13. MG

    2019 Toyota Rav4 Abnormal Buzz/Groan Noise 20 – 30 mph From Rear Differential T-SB-0009-20

    This Bulletin is Now Obsolete....See T-SB-0009-20 Some 2019 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the rear differential assembly at 20 – 30 mph when accelerating from a stop and/or at 20 – 13 mph on deceleration after driving...
  14. OishiiJPN

    Toyota Rav4 Hybrid Pedestrian Automatic Warning system noise

    Manufacturers must install an AVAS (Acoustic Vehicle Alerting Systems) system in four-wheeled electric and hybrid electric vehicles that are approved from July 1, 2019, and to all new quiet electric and hybrid vehicles registered from July 2021. The vehicle must make a continuous noise level of...
  15. Dread Pirate Roberts

    2019 Toyota Rav4 Hybrid Fuel Gauge Tank Concern Tech Tip T-TT-0581-19

    Some 2019 model year RAV4 HV customers may be experiencing some concern related to fuel gauge reading less than full. Please note, this communication refers to 2019 RAV4 HV customers only. The meter may display somewhere around 3/4 or 7/8 full at time of gas station pump auto stop. See Tech Tip...
  16. Dread Pirate Roberts

    Some 2019 Toyota RAV4 Hybrids may not accept a full tank of fuel

    Also see Tech Tip T-TT-0581-19 The 2019 Toyota RAV4 Hybrid could have a fuel tank issue that prevents owners from completely filling it up, according to a report from Automotive News. Toyota has issued a statement to confirm it is “investigating a fuel tank shape issue on certain RAV4 Hybrid...
  17. MG

    2019 Toyota RAV4 AWD Warning Light ON DTC C13F800

    Some 2019 model year RAV4 vehicles may exhibit an AWD Warning Light/Message ON condition with Diagnostic Trouble Code (DTC) C13F800 (4WD/AWD Rear Disconnect System Performance) present. Follow the Repair Procedure in bulletin T-SB-0086-19 to address this condition. Note: This Service Bulletin...
  18. Lewis

    2016-2018 Toyota RAV4 Hybrid with code P0A45 Drive Motor “B” Position Sensor Circuit

    Some 2016 – 2018 model year RAV4 Hybrid vehicles may exhibit a hybrid system warning message MIL ON condition with Diagnostic Trouble Code (DTC) P0A45 (Drive Motor “B” Position Sensor Circuit) present. Follow the Repair Procedure in T-SB-0079-19 bulletin to address this condition. Replace...
  19. MG

    2019 Toyota RAV4 Hybrid Flutter Rattle Noise From HV Battery Cooling Fan

    Some 2019 model year RAV4 Hybrid vehicles may exhibit a flutter/rattle noise during vehicle operation from the HV battery cooling fan. A new HV battery intake duct has been developed. Follow the Repair Procedure in bulletin T-SB-0077-19 to address this condition. R & R Hybrid Battery Intake...
Top